Interpretation ID: nht93-2.7

DATE: 03/04/93

FROM: JOHN WOMACK -- ACTING CHIEF COUNSEL, NHTSA

TO: ROBERT A. ERNST -- RESEARCH COORDINATOR, I-CAR TECH CENTER

TITLE: NONE

ATTACHMT: ATTACHED TO LETTER DATED 1-19-90 FROM STEPHEN P. WOOD TO LINDA L. CONRAD (STD. 208); ALSO ATTACHED TO LETTER DATED 2-4-93 FROM ROBERT A. ERNST TO CHIEF CONSUL, NHTSA (OCC 8302)

TEXT: This responds to your February 4, 1993, letter concerning possible legal obligations to repair an air bag system following a collision. You stated that your organization produces technical training for the automotive collision repair industry and has received a number of inquires concerning this issue. Your specific questions are addressed below. Where two questions concern a common issue, they are addressed by a single response.

1. Are there Federal regulations which specifically direct the collision repair facility to restore the supplemental restraint system to an operable condition following a deployment on vehicles the facility repairs?

4. Can the vehicle be sold if the owner knows that the supplemental restraint is inoperable because of a previous deployment?

I am enclosing a copy of a January 19, 1990, letter to Ms. Linda L. Conrad which addresses the issue of possible legal obligations to repair a deployed air bag following a collision. As explained in that letter, Federal law does not require replacement of a deployed air bag in a used vehicle. In addition, there is no Federal law that prohibits selling a used vehicle with a supplemental restraint that is inoperable because of a previous deployment. However, our agency strongly encourages dealers and repair businesses to replace deployed air bags whenever vehicles are repaired or resold, to ensure that the vehicles will continue to provide maximum crash protection for occupants. Moreover, a dealer or repair business may be required by state law to replace a deployed air bag, or be liable for failure to do so.

2. If repairs are deliberately made to mask the fact that the air bag system is inoperative, has the repair facility violated any applicable laws?

Section S4.5.2 of Standard No. 208 requires a readiness indicator for an air bag system which is clearly visible from the driver's seating position. After an air bag is deployed, this indicator would show that the air bag system is not operative. Section 108(a)(2)(A) of the National Traffic and Motor Vehicle Safety Act (15 U.S.C. 1397 (a) (2) (A)) provides that:

No manufacturer, distributor, dealer, or motor vehicle repair business shall knowingly render inoperative, in whole or in part, any device or element of design installed on or in a motor vehicle . . . in compliance with an applicable Federal motor vehicle safety standard.

As explained in the Conrad letter enclosed, this provision does not impose an affirmative duty on a repair business to replace an air bag that was damaged in a crash. However, this section would prohibit the repair business from removing, disabling, or otherwise "rendering inoperative" the readiness indicator. Any violations of this "render inoperative" prohibition in the Safety Act would subject the violator to a potential civil penalty of up to $ 1,000 for each violation.

3. If the owner of the vehicle requests that the supplemental restraint not be restored to operational condition, is the owner of the repair facility or the vehicle liable for later injuries?

Liability risk is a question of state law, not of Federal law. Therefore, a repair business should consult an attorney in its state about this question. I hope you find this information helpful. If you have any other questions, please contact Mary Versailles of my staff at this address or by phone at (202) 366-2992.