Interpretation ID: aiam5432
Engineering Services Blue Bird Body Company P.O. Box 937 Fort Valley
GA 31030;
"Dear Mr. Turner: This responds to your letter of May 2, 1994 requesting an interpretation of how the term 'daylight opening,' as used in a recent amendment of Standard No. 217, Bus Emergency Exits and Window Retention and Release, would apply to various exits (57 FR 49413, November 2, 1992, and 57 FR 57020, December 2, 1992). Your letter references a March 24, 1994 interpretation letter to Mr. Bob Carver of Wayne Wheeled Vehicles. That letter discussed the term 'daylight opening' as follows: The term 'daylight opening' is defined in the Final Rule as 'the maximum unobstructed opening of an emergency exit when viewed from a direction perpendicular to the plane of the opening.' An obstruction in this context would include any obstacle or object that would block, obscure, or interfere with, in any way, access to that exit when opened. In determining the 'maximum unobstructed opening of an emergency exit,' we would subtract, from the total area of the opening, the area of any portions of the opening that cannot be used for exit purposes as a result of the obstruction. The area measurements would be taken when viewed from a direction perpendicular to the plane of the opening. Your letter states that this interpretation represents a drastic change in what we understood from the wording of the final rule ... and what we were told by Rulemaking. We believed and were told that the definition of daylight opening applied to the exit opening itself and did not involve access to the opening. Access to and obstruction of openings are addressed later in the standard in section S5.4.2 School Bus Emergency Exit Extension. Before answering your specific questions, I would like to respond to these statements. You are correct that S5.4.2 includes requirements related to access to, and obstruction of, exits in that it specifies the minimum opening and the minimum amount of access required for various exits. However, the issue of minimum opening is separate from the issue, addressed in S5.2.3, of the maximum amount of area credited for any opening. Section S5.2.3 specifies the number and type of exits required on school buses. This section states: The area in square centimeters of the unobstructed openings for emergency exit shall collectively amount to at least 432 times the number of designated seating positions in the bus. The amount of emergency exit area credited to an emergency exit is based on the daylight opening of the exit opening. Thus, S5.2.3 specifies the maximum amount of area credited for any opening. An interpretation of the term 'daylight opening' that allowed credit for the exit opening, regardless of obstructions, would be contrary to the plain language of the definition of that term. Giving credit for obstructed areas would also be contrary to the intent of the final rule, which is to increase the area on larger buses which is available for exit in an emergency. With respect to your report of receiving an oral interpretation from agency staff, I would also like to emphasize that, to the extent the public has any questions concerning the meaning of any NHTSA standard or regulation, the only agency interpretations which are authoritative and which therefore can be relied upon by members of the public, such as manufacturers, are those issued in writing by the Chief Counsel. We have reminded agency staff not to make formal, or informal, oral statements that might misinterpreted by manufacturers as official agency guidance on which they may safely rely. Your letter states that the March 24 interpretation 'raises other questions regarding the various school bus emergency exits.' Your questions and the response to each follows. By way of background information, NHTSA does not approve motor vehicles or motor vehicle equipment. The following represents our opinion based on the facts provided in your letter. Rear Emergency Exit Door a. Section S5.4.2.1(a)(1) ... requires unobstructed passage of a rectangular parallelepiped 30 centimeters deep. It is our rationale and interpretation that a seat back or other interior component that lies forward of this 30 centimeter deep parallelepiped is not an obstruction to the rear emergency door and would not result in a reduction of the area credited to the rear emergency door. (See figure 1a) Is this interpretation correct? In the case of a rear emergency exit door, the depth requirement in S5.4.2.1(a)(1) reflects a determination that an interior component outside that limit does not render the exit unusable. Therefore, an interior component outside the area bounded by the transverse vertical plane of the exit opening, the two longitudinal vertical planes tangent to the sides of the exit opening, and the transverse vertical plane parallel to and 30 centimeters away from the plane of the exit opening would not be considered an obstruction for determining the area of 'daylight opening.' b. School buses are typically equipped with 39-inch (99 cm) wide seats. At the rear emergency door, one of the rear seats is typically shifted forward to provide the clearance required by S5.4.2.1(a)(1). The other rear seat is typically allowed to be near or against the rear wall of the bus to fully utilize the available seating floor space and to provide maximum knee clearance. When viewed from the rear, this seat protrudes into the door opening, and according to the (March 24) interpretation ..., the area of the obstruction would not be credited to the exit. Following the logic of the interpretation, the area of the seat itself and the area above the seat could not be credited. We disagree with the logic of the interpretation that door exits are only used by movement along the floor. If the bus is on its side or top, the exit must be used from different approaches. It is therefore our logic and interpretation that only the actual area obstructed (i.e. the area of the seat and the area below the seat) cannot be credited to the exit. For the case in question, the area above the seat can be used in many accident scenarios and therefore can be credited as 'daylight opening.' (See figure 1b) Is this interpretation correct? You are correct that emergency doors will be used by people moving along an interior surface other than the floor if the vehicle is on its side or roof following an accident. As stated in the March 24 interpretation, in determining the amount of daylight opening, you should not credit any area which 'cannot be used for exit purposes.' In the case of the seat illustrated in incoming letter from Wayne, the area over the seat is 6.12 inches by 12.5 inches. However, in reviewing that letter in light of your question, we now agree that the area over the seat may be usable in some accident scenarios. For your exit, neither your letter nor figure 1b provide dimensions of the area over the seat. If the area is large enough to be usable in an accident scenario, that area can be credited towards the daylight opening. c. The rear emergency door on Blue Bird school buses is hinged on the outside, and the top portion of the door is angled forward when the door is closed. When the door is opened and held in the open position by the device required by S5.4.2.1(a)(3)(i), the door protrudes into the exit opening when viewed from a direction perpendicular to the plane of the opening. It is our understanding, based on the interpretation of reference 3, that the protrusion of the door now constitutes an obstruction and the area of the obstruction cannot be credited to the exit area. (See figure 1c) Is this understanding correct? This is correct. Emergency Window Exits The seat backs of school bus seats can protrude into the lower region of side window exit openings. Side window exits when the bus is upright may be used by climbing over the seats. If the bus is on its side or top, the side window exits may be used from different approaches. Since areas of sufficient size above, in front of, and behind a protruding seat back could be used for different parts of the body, (i.e. head, knees, legs) when crawling out a side window exit in different vehicle orientations, it is our logic and interpretation that only the actual area of the seat back in the side window exit opening and the smallest area bounded by the seat back, a horizontal plane tangent to the top of the seat back, and the edges of the exit opening constitute obstructions and cannot be credited to the exit. (See figure 2) Is this interpretation correct? In your illustrations, the area obstructed by the seat back protruding into the window opening clearly cannot be credited to the daylight opening. Whether area above or forward or rearward of the seat back can be credited depends on whether the size of the area is sufficient to be used in exiting the vehicle. Any of these areas which permits passage of the ellipsoid proposed in a December 1, 1993 notice of proposed rulemaking indicates that these areas clearly should be credited (58 FR 63321, see proposed S5.4.2.1(c)). NHTSA proposed this because it believed it reflected the minimum size window which could be used as an exit. If not cut off by obstructions from other unobstructed areas of the daylight opening of the window, as viewed in a plan view, it may be possible that smaller areas should also be credited. In all of the illustrations in figure 2, the seat back extends less than halfway up in the opening. Therefore, it appears that the area above the seat would be credited. We also agree that if the seat protrudes near the front or rear edge of the window opening, it is unlikely that the area between the seat back and the nearest edge of the opening would be usable. However, one of your illustrations shows the seat back protruding near the center of the window opening. In such an instance, it may be possible that the area on each side of the seat back is large enough to be usable. For example, a person might use the window by climbing over the seat, with either their legs straddling the seat, or their head and torso over one side of the seat and their legs over the other. Side Emergency Exit Doors Following the logic presented above regarding the use of emergency exits in different vehicle orientations, we disagree with the interpretation that area A2 (an area bounded by a horizontal line tangent to the top of the seat back, a vertical line tangent to the rearmost portion of the top of the seat, the upper edge of the door opening, and the edge of the door forward of the seat) ... is not usable. In fact even when using the side emergency door when the vehicle is upright, a person would likely lean over the seat back and hold on to the seat, thus using area A2. Figure 3 enclosed is drawn more to scale than the illustration used in (the March 24 interpretation). We suggest the Agency review this illustration, conduct field research by using the exits in real buses, and then reconsider the interpretation ... regarding side emergency doors. We recommend that area A2 be credited as 'daylight opening' for a side emergency door. As explained in our response to question b on rear emergency exit doors, the area above some seats may be large enough to be credited toward the daylight opening. Front Service Door a. The lower portion of the grab handle on many school bus front service doors protrudes into the exit opening when viewed from a direction perpendicular to the plane of the opening. (See figure 4) Based on the (March 24) interpretation ..., we understand that this protrusion now constitutes an obstruction. Is this understanding correct? This is correct. b. The front service door of most school buses leads to a stepwell and steps used to enter the bus. On front engine transit style school buses, the steps are typically angled to the rear and the riser to the first step is just a few inches inboard of the door opening. It is our logic and interpretation that steps in a stepwell do not constitute an obstruction and their presence does not reduce the area credited to the entrance door opening. (See figure 4) Is this interpretation correct? The steps provide the means of using the door, allowing a person to move between the ground and the floor level of the bus. They do not 'block, obscure, or interfere with, in any way, access' of occupants descending to the front service door. Therefore, although they are visible in the doorway when the doorway is viewed in a plan view, the steps are not obstructions within the meaning of the definition of daylight opening. I hope you find this information helpful. If you have any other questions, please contact my staff at this address or by phone at (202) 366-2992. Sincerely, John Womack Acting Chief Counsel";